crwdns2936637:0crwdne2936637:0 crwdns2853008:0crwdne2853008:0 crwdns2861143:0crwdne2861143:0

Jazz UltraTab C1059-HL Speaker Replacement

crwdns2915892:0crwdne2915892:0

This guide will guide the user to effectively remove and replace the speaker. This replacement will take around 15-20 minutes. However, if the guide is followed to the letter, the task will be accomplished with minimal damage to the device.

crwdns2942213:0crwdne2942213:0

  1. Jazz UltraTab C1059-HL Speaker Replacement, Speaker: crwdns2935265:01crwdnd2935265:01crwdnd2935265:02crwdne2935265:0 Jazz UltraTab C1059-HL Speaker Replacement, Speaker: crwdns2935265:01crwdnd2935265:02crwdnd2935265:02crwdne2935265:0

    • Start by removing the back panel.

    • Remove the 4 screws holding the device together: two on the left side, and two on the right side.

    • Using a metal spudger, carefully pry open the case.

    • With the screws gone, the case is held together with clips along the outside edge of the aluminum backplate.

    • Undoing these clips can take a bit of force. Be cautious not to damage the plastic edge of the device.

    crwdns2913378:0crwdne2913378:0

  2. Jazz UltraTab C1059-HL Speaker Replacement: crwdns2935265:02crwdnd2935265:01crwdnd2935265:01crwdne2935265:0

    • Place the device on the table with the screen-side down.

    crwdns2913378:0crwdne2913378:0

  4. Jazz UltraTab C1059-HL Speaker Replacement: crwdns2935265:03crwdnd2935265:01crwdnd2935265:01crwdne2935265:0

    • This is the Speaker.

    • Remove the two black screws.

    crwdns2913378:0crwdne2913378:0

  5. Jazz UltraTab C1059-HL Speaker Replacement: crwdns2935265:04crwdnd2935265:01crwdnd2935265:01crwdne2935265:0

    • Remove black tape from the wires.

    • Keep this tape, you will need it for reassembly.

    crwdns2913378:0crwdne2913378:0

  6. Jazz UltraTab C1059-HL Speaker Replacement: crwdns2935265:05crwdnd2935265:01crwdnd2935265:01crwdne2935265:0

    • Using a soldering iron, heat up the spot where the speaker wires connect to the mainboard.

    • Remove Speaker wires when the solder liquifies.

    • Remember to make note of where each wire is connected. When reinstalling the speaker, it is important that the wires are reattached to the same spot.

    crwdns2913378:0crwdne2913378:0

  7. Jazz UltraTab C1059-HL Speaker Replacement: crwdns2935265:06crwdnd2935265:01crwdnd2935265:01crwdne2935265:0

    • Remove the speaker.

    • Replace the speaker by following these steps in reverse.

    crwdns2913378:0crwdne2913378:0
crwdns2915888:0crwdne2915888:0

To reassemble your device, follow these instructions in reverse order.

crwdns2935227:0crwdne2935227:0

crwdns2862417:0crwdne2862417:0

crwdns2935293:0crwdnd2935293:04crwdnd2935293:0crwdne2935293:0

Tim Poe

crwdns2935283:009/26/15crwdne2935283:0

361 crwdns2915208:0crwdne2915208:0

crwdns2935297:03crwdne2935297:0

crwdns2918514:0crwdne2918514:0: 8

crwdns2935301:05crwdne2935301:0

crwdns2915084:0crwdne2915084:0

IUPUI, Team 1-3, Wilson Fall 2015 crwdns2935289:0IUPUI, Team 1-3, Wilson Fall 2015crwdne2935289:0

IUPUI-WILSON-F15S1G3

crwdns2931471:04crwdne2931471:0

crwdns2935297:06crwdne2935297:0

crwdns2944067:00crwdne2944067:0

crwdns2917038:0crwdne2917038:0

crwdns2936625:0crwdne2936625:0:

crwdns2936751:024crwdne2936751:0 0

crwdns2936753:07crwdne2936753:0 0

crwdns2936753:030crwdne2936753:0 4

crwdns2942667:0crwdne2942667:0 97